Jump to content

AdBlue tank fault


haggis_
 Share

Recommended Posts

Recently bought an A4 Avant Quattro, perfect service history and well looked after at 73,000 miles. 2 months in with limited miles and I get an AdBlue fault and CEL on dash. 

Car is now in with Audi needing the AdBlue tank replaced, thankfully the car had a few months left on approved used warranty so is covered.

After researching it seems like such a common issue. Does the new part have the 2 year part warranty? Love the car but it was bought for trips down to Europe and this is not filling me with confidence. 

Link to comment
Share on other sites


It is a very common issue on vag cars as well as other manufacturers. My wife has a jaguar xe and it's also known for faults. Hence why in our case we get Jag tecs to fill the adblue tank up when it need it with genuine adblue. That way they can't blame us for over filling it or putting wrong fluid in it etc. It has saved us expensive bills twice when the system has gone wrong and Jag have had to drain the tank and reset the system FOC. Even though the car is well out of warranty. 

Link to comment
Share on other sites

  • 3 weeks later...
  • 2 weeks later...
1 hour ago, Steve Q said:

No way! What are they doing/not doing? 

One of/all of the parts is on backorder with no ETA. So car has been off the road at Audi for 5 weeks now. Luckily we have a little run around but I was hoping to get rid or scrap it soon as its on its way out. I've been pretty patient with the dealer, not their fault and not much to be done, my only issue with them is that it's impossible to get through to the service advisor. I've literally called over 30 times to be told I'd get a call back but that never happens. 

Feeling annoyed, I rang today and made a fuss, which is unlike me! I finally received a call back and was informed parts are still on back order. As I've been patient they are trying to sort me out with a loaner until this is all sorted, I'd normally refuse but this time I'll take it and enjoy it. 

Link to comment
Share on other sites

  • 3 weeks later...

Hi,I have similar problem appear today  - Adblue saying 650 miles and the emissions control warning light on amber. I have it booked in with a local garage Thurs to run through diagnostics however he didn’t sound too optimistic when I explained the fault. Anyone have any ideas what kind of cost I could be looking at? 🙈

Link to comment
Share on other sites

24 minutes ago, GavinC said:

Hi,I have similar problem appear today  - Adblue saying 650 miles and the emissions control warning light on amber. I have it booked in with a local garage Thurs to run through diagnostics however he didn’t sound too optimistic when I explained the fault. Anyone have any ideas what kind of cost I could be looking at? 🙈

If the pump has gone you'll be looking at 2k for replacing the pump and AdBlue tank as they are integrated. However it's covered if you have a warranty. 

Link to comment
Share on other sites

It’s being looked at today to have diagnostic but strangely yesterday the Adblue warning changed to 4500 mile until refill, then this morning the engine management light and Adblue warning both went off. Then on way to dropping at garage the 650 miles warning came on again but the engine mgt light remained off!(?). Do you think this sounds like a sensor fault? Cheers 

Link to comment
Share on other sites

16 hours ago, GavinC said:

It’s being looked at today to have diagnostic but strangely yesterday the Adblue warning changed to 4500 mile until refill, then this morning the engine management light and Adblue warning both went off. Then on way to dropping at garage the 650 miles warning came on again but the engine mgt light remained off!(?). Do you think this sounds like a sensor fault? Cheers 

Yeah sounds like the sensor in the tank, same thing happened to me. The fault would show on the dashboard disappear and then eventually it came back and stayed on. 

Link to comment
Share on other sites

8 hours ago, haggis_ said:

Yeah sounds like the sensor in the tank, same thing happened to me. The fault would show on the dashboard disappear and then eventually it came back and stayed on. 

 

Link to comment
Share on other sites

  • 1 month later...

I have had this problem with a 3.2 diesel A4 AllRoad, in spite of filling it right up. Taken it to an independent VAG specialist who says that I need a new sensor. However, the new sensor would need to work with a new pump and they don't make the integrated pump and tank any more so I would have to renew the whole system: parts, fitted, programmed = £2500. Parts not currently available. Or... I could disconnect it and use the car and decided on this. Was rung back to say that it now gives 310bhp as opposed to the original 218! Cost around £300. Result. Someone suggested that this was the state of the car industry: no one is selling new cars because of the confusion over electric cars so they need to make money on spares. They therefore  update spares so a whole unit has to be fitted, rather than what you need. That's how they're making their money. 

Link to comment
Share on other sites

  • 1 month later...
4 hours ago, Gooders said:

I have got this snag now. Bag com says pump fault. Any update on spares ? 

Hi you can always get the adblue mapped out, end of problem.

Steve.

Link to comment
Share on other sites

22 hours ago, Gooders said:

I have heard this messes up the Dpf regen ? 

 

22 hours ago, Gooders said:

I have heard this messes up the Dpf regen ? 

Hi no if you look at the dynamics of SCR the adblue only converts the Nox particles from one to two the addition of a 80% water solution into the steam makes the oil soot particles sticky and harder to burn, I am thinking of having mine deleted and there is nothing wrong with my system the car is now on its third EGR cooler which like the others was blocked with adblue crystals and a sticky tar like mess that hasn't been burned properly and at about £900 every fifteen months is bordering on stupid, the thing that screws the DPF is if you have theEGR mapped out as that allows the gas to be a lot hotter and start to melt the Turbo 

 

Steve.

Link to comment
Share on other sites

20 hours ago, Gooders said:

May be worth a look then. Would it show on mot etc ? 

Hi no as there is no plan to introduce Nox testing equipment in to the MOT test because the world of government thinks we are all going to be charging around in electric cars in another seven years, where's the charging infrastructure.

Steve.

Link to comment
Share on other sites

  • 3 months later...
  • 4 months later...
On 5/24/2023 at 8:17 PM, Stevey Y said:

Hi you can always get the adblue mapped out, end of problem.

Steve.

I got this advice from the local garage where they look after two of my Audi cars. However, reading the other sites does not recommend doing so. I am confused.

On 2/14/2023 at 6:57 PM, Stevey Y said:

Hi they have probably told him it needs a new tank, much more fun and money from their perspective.

Steve.

They quoted me £2070 to replace a new tank and module while the agreement of Hire Purchase (HP) hasn't ended yet. The Audi dealer doesn't care about that unreasonable matter.

Link to comment
Share on other sites

20 hours ago, Tom Ng said:

I got this advice from the local garage where they look after two of my Audi cars. However, reading the other sites does not recommend doing so. I am confused.

They quoted me £2070 to replace a new tank and module while the agreement of Hire Purchase (HP) hasn't ended yet. The Audi dealer doesn't care about that unreasonable matter.

Hi depending on when you purchased the car you can go to trading standards and they may pick up the flag and petition them under the fit for purpose act, Audi wont care but if you also email VAG customer service they may well help you as they are not fans of this type of thing, I did the same last year when one of their approved franchise TPS were running me ragged over a part, the car was suspended on a four poster ramp for four days waiting for the part which was already paid for and was suddenly on back order three weeks so I emailed VAG customer services and explained my problem and dissatisfaction, the next day the part arrived with a red faced area manager who demanded to know who Steve was, the guy that put in the complaint, I stepped straight up and explained why, he went for the sympathy vote saying how much trouble I caused him, my heart bled for him not, VAG take things like this seriously its bad PR for them.

Steve.

  • Thanks 1
Link to comment
Share on other sites

12 hours ago, Stevey Y said:

Hi depending on when you purchased the car you can go to trading standards and they may pick up the flag and petition them under the fit for purpose act, Audi wont care but if you also email VAG customer service they may well help you as they are not fans of this type of thing, I did the same last year when one of their approved franchise TPS were running me ragged over a part, the car was suspended on a four poster ramp for four days waiting for the part which was already paid for and was suddenly on back order three weeks so I emailed VAG customer services and explained my problem and dissatisfaction, the next day the part arrived with a red faced area manager who demanded to know who Steve was, the guy that put in the complaint, I stepped straight up and explained why, he went for the sympathy vote saying how much trouble I caused him, my heart bled for him not, VAG take things like this seriously its bad PR for them.

Steve.

Hi, Thanks for your story. I have a naive question: what is VAG?

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

 Share




×
×
  • Create New...

Forums


News


Membership